Intermittent ABS DTCs

May 15, 2017
This bulletin applies to 2005-2009 Chevy Uplander vehicles, as well as 2005-2007 Buick Terraza, 2005-2009 Pontiac Montana SV6 and 2005-2008 Saturn Relay models.

This bulletin applies to 2005-2009 Chevy Uplander vehicles, as well as 2005-2007 Buick Terraza, 2005-2009 Pontiac Montana SV6 and 2005-2008 Saturn Relay models.

Chevy’s tech center (TAC) has received several calls in regards to intermittent DTCs C0460, C0461 (steering position sensors). C-187 (lateral accelerometer circuit range/performance), C0196 (yaw rate circuit) and/or C0252 (VSES sensor uncorrelated). Initial investigation has found that the forward engine harness routed from the EBCM, underneath the inlet air breather box and across/down the transmission, may have several points where it may come into contact with the transmission stud or A/C line, creating a short to ground.

Inspect the complete forward engine wiring harness and repair as needed. Wrap protective tape inside and outside the conduit. The harness should be re-routed to avoid contact with the A/C accumulator, transmission mounting studs and/or any sharp edges.

Sponsored Recommendations

Learn how electronic parking brake actuators have replaced manual systems and now play a key role in advanced safety features like automatic emergency braking. This WIYB Training...
Not all fuel injectors are created equal. In this WIYB Training Series, we compare Standard® Fuel Injectors against OE, low-cost imports. See why precision engineering and rigorous...
Carrying active OEM subscriptions for all manufacturers is not possible for many shops. However, access to this software is required for certain modern vehicles and repairs, and...
Enhance your collision repair workflow with Autel’s IA900, a process-driven solution integrating precision alignment, bi-directional diagnostics, and ADAS calibration. Designed...

Voice Your Opinion!

To join the conversation, and become an exclusive member of Vehicle Service Pros, create an account today!